Polpriklopnik s premičnim dnom

FLIEGL SDS 390 Schubboden 101 m³ / Walkingfloor

The images are archive photos; the vehicle may still be in use!

Vehicle consists of:
Chassis semi-trailer for freight forwarding
Fine-grain steel welded lightweight construction to the support legs, fifth wheel plate with replaceable 2-inch kingpin
24 t 2-speed landing gear, single-side operation, with straight lower part
Pull-out ladder at the rear
Side door holders
2 wheel chocks with holder
Side underrun protection, aluminium
Guodsy Snmpopfx Apbob
Rear underrun protection, steel, with wide Fliegl mud flaps
Foldable mudguard for lighting unit
Quarter shell mudguards
Rear impact protection
Tarp rod with bracket
1 plastic toolbox

Axles & Suspension
3 BPW disc brake axles
"Axle/chassis laser alignment" – reduces tyre wear and fuel consumption
Air suspension

Brake System
2-line compressed air braking system
Coloured hose runs for easy maintenance
Spring-type parking brake
Duomatic
EBS, electronic braking system with EBS socket at the front, no connecting cable
Note: The trailer must only be towed by tractors that guarantee the effectiveness of the ABS!
With lift & lower valve
Vehicle - Driving Stability System
AAC Basic, automatic lift axle on the last axle, acts as shunting aid up to 20 km/h, manually switchable
Axle load detection via EBS CAN bus signal

Wheels and Tyres
385/55 R22.5 – make at manufacturer’s choice

Electrics
24 Volt, multi-chamber lights, side-mounted yellow LED lighting
Side yellow LED lighting connected to indicator “flashing side markers”
2 white front position lights
2 white/red lane departure lamps at the rear
2 x 7-pin and 1 x 15-pin misconnection-proof sockets at the front, no connecting cable

SB Hydraulics
Hydraulic cylinder with sliding mechanism integrated into the floor. 2-circuit hydraulics.
Direction change (forward/reverse) is electrically operated by wired remote control.
Hydraulic actuation via truck PTO
Hydraulic connection with hose at front wall and HDK screw connector
Recommended pump capacity:
Flow rate: 110 l/min
Pressure: 250 bar
Min. oil tank capacity: 100 l

Floor planking made of aluminium, 8 mm profiled, grooved
Aluminium box body from high-quality, wear-resistant material. Front and side walls made from aluminium hollow profiles, all round at the top welded with a wide special reinforcement profile in aluminium
Sliding wall for easier unloading, with reinforced tarpaulin at the bottom
Rear wall from aluminium hollow profiles, double-winged door divided 1/2 to 1/2, with special U-profile frame with stop and rubber gasket all round, 2 external swing bolt locks, locked top and bottom. Rear wall with mechanical safety lock, operation at the rear on the left in direction of travel, with pivoting crossbar at top.
Standing platform with ladders on both sides
3 removable, swivel crossbars for tarp support
Sliding sheet, stowable on one side, with 2 longitudinal tensioning straps, 3 ratchet straps at the side

Operating Instructions
Special permit required if total hitch length exceeds 16,500 mm.

Country of Registration / Plates
Germany
with Dekra inspection and certificate (§13 EC-FGV)
Warning sign "Long HGV"
Long-HGV combination inspection certificate
Driver instruction at Triptis factory for up to 4 persons per truck combination

Paintwork
Frame: DB 7350 Novagrau
tipper body: aluminium natural finish
Tarpaulin: RAL 7035 light grey

Oglas je bil avtomatsko preveden. Možne so napake pri prevodu.